|
#1
|
|||
|
|||
ZF 4HP22 tranmission servicing recommendations
My Volvo came with a large collection of service records and repair slips but in reviewing the large folder I cannot determine when the transmission was last serviced.Knowing this I think it prudent to drain the fluid and replace the filter. I do not have a green book for this information so naturally I do have a few questions:
Thank you for the replies.
__________________
Jim 1985 Volvo 740 GLE turbo diesel |
#2
|
|||
|
|||
This is a little embarrassing, but I usually replace the whole trans.there is some point to pulling a cooler line, and running the engine to pull clean form one bucket while exhausting dirty into another. you only get 1/3 of the fluid out dropping the pan.
DexronIII or better |
#3
|
|||
|
|||
I wouldn't replace the filter. Should be good to go with a visual inspection. There was a later Volvo tech bulletin that stated not to replace the filter. Reverse blow w/ shop air (messy!).
Clean well the pan and magnets. Note the clamps are different for the corners. Don't overtorque. 745 TurboGreasel reminded me of a method I have used in the past to flush all the ATF, which worked well. Not wanting to admit it, but I used Supertech Dexron III from Walmart. And 1/2 to 2/3 bottle of Lucas Trans Fix, to atone. http://www.lucasoil.com/products/dis...iid=29&catid=2
__________________
1985 744 gle d24t 1985 745 gle d24t |
#4
|
|||
|
|||
Quote:
Does the torque convertor hold the remaining 2/3rd's of the fluid?
__________________
Jim 1985 Volvo 740 GLE turbo diesel |
#5
|
|||
|
|||
The filter is just a mesh screen, not a filter per se. I don't see a reason necessarily to *not* replace it though. Wonder why Volvo would have recommended blowing it out instead?
You can find a kit that includes a filter, O-ring, and pan gasket as a set, this is the easiest way IMO. Tranny service is worth doing, I like to know what it looks like inside the pan anyway. I have used the "transfusion" method as well. Never tried putting an "in" hose in a clean bucket as well as the "out" hose in the dirty bucket to receive old fluid -- I'm not sure it works that way, haven't ever looked at the tranny diagrams but I have always just done it by letting it pump old fluid out a cooler line and adding new through the dipstick tube. I don't know if the trans will "suck" from the other side of the cooler or if it just returns from the cooler circuit back into the sump under pressure from the feed side. The times when I have wanted to really thoroughly refresh one, I usually start by doing a pan/filter service, drain all fluid out from that point, clean pan and magnets, make sure everything looks cool in there, reseal with new gasket, and fill with new fluid, *then* begin the transfusion process after that. This way you start the job already halfway done and don't waste as much new fluid mixing it in and pumping it out with the old. Good to do this part with the rear wheels off the ground and trans in neutral since ZF doesn't like prolonged idling or revving in P or N when the output shaft is stopped. This way you can just let the rear wheels spin if they want without having to worry. Seems like most wisdom about these is that synthetic fluid is not worth the money, better to use DexII+ fluid as cheap as you like, and drain/fill often to keep it clean. 297k on the original unit in my DD, still does what it's supposed to, though the 1-2 shift is a little firm at part throttle. They can last a long time if cared for. |
#6
|
|||
|
|||
Kit
|
#7
|
|||
|
|||
Just so I have this right I would disconnect a line going from the transmission to the radiator and place into a bucket. Then start the car with the rear wheels raised and in gear. At this point transmission fluid will start draining into the bucket, presumably a "dirty" color. As it drains I replace with fresh fluid via the dipstick hole?
Do I keep this up until the fluid exiting the transmission is a new/clean color? How will I know how much fluid to add during the process?
__________________
Jim 1985 Volvo 740 GLE turbo diesel |
Tags |
4hp22, transmission filter, transmission fluid, transmission service, zf 4hp22, zf auto |
|
|